在線咨詢
官方二維碼
當前位置：
2023.09.20
靜音型發電機在安裝調試時要注意什么？
首先合上發電機的控制箱內的保險箱后，然后按下啟動按鈕。如果出現啟動不成功時，等待一定時間后，再次按下啟動鍵。
First, close the safety box in the control box of the generator, and then press the start button. If the startup fails, wait for a certain amount of time before pressing the start button again.
啟動發電機時應該對發電機的郵箱壓力進行觀察，如果油壓沒有顯示很指數低時，應立即停止并檢查。
When starting the generator, the pressure in the generator's mailbox should be observed. If the oil pressure does not show a very low index, it should be immediately stopped and checked.
大功率靜音型發電機啟動后，控制箱的各項參數進行檢查。包括：機油壓力水溫電壓頻率。
After starting the high-power silent generator, check the various parameters of the control box. Including: oil pressure, water temperature, voltage frequency.
通常情況下，機組啟動后轉速直接達到額定轉速；怠速時間不易過長，一般為3~5min。否則會對發電機的相關元器件燒壞，導致無法使用。
Usually, after the unit starts, the speed directly reaches the rated speed; The idle time is not easy to be too long, usually 3-5 minutes. Otherwise, it will burn out the relevant components of the generator, causing it to be unusable.
檢查機組油路水路及電器的是否出現滲漏情況；
Check if there is any leakage in the oil, water, and electrical circuits of the unit;
檢查發電機機組各連接處的緊固情況，看有無松動和劇烈振動
Check the tightness of each connection of the generator unit for looseness and severe vibration
觀察機組各種保護和監視裝置是否正常；
Observe whether various protection and monitoring devices of the unit are normal;
當轉速達到額定轉速，起空載運行的各項參數穩定后，合閘送電
When the speed reaches the rated speed and all parameters for starting and no-load operation are stable, close the power supply
檢查確認控制屏各項參數是否在允許的范圍內，再次檢查機組的振動，有無三漏及其它故障
Check and confirm whether the parameters of the control screen are within the allowable range, and recheck the vibration of the unit for any three leaks or other faults
柴油發電機運行時嚴禁超負荷
Overloading is strictly prohibited during the operation of diesel generators
認真填好柴油發電機調試表格，一式二份各自保存，與操作人員交代注意事項以及調試知識培訓。
Carefully fill out the diesel generator debugging form, keep two copies each, and explain the precautions and debugging knowledge training to the operators.
感謝您的閱讀，此文的文章來源：瓦斯發電機組更多的內容和問題請點擊：http://www.hdlelisa.com我們會繼續努力的為您提供服務，感謝您的支持！
Thank you for reading. The source of this article is: Gas Generator Set. For more information and questions, please click on: http://www.hdlelisa.com We will continue to work hard to provide you with services. Thank you for your support!
上一篇： 瓦斯發電機組為什么都是用低濃度？
下一篇：汽輪發電機組振動現場診斷