為了延長焦化發電機組運行安全性和使用壽命，對機組定期進行維護保養是必要的，如果能遵守機組維護保養的相關條例，就可保證機組的性能。

In order to extend the operation safety and service life of the coking power generation unit, it is necessary to regularly maintain the unit. If the relevant regulations on unit maintenance can be observed, the performance of the unit can be guaranteed.

（1）每天保養：

(1) Daily maintenance:

1、檢查焦化發電機工作日報。

1. Check the daily work report of coking generator.

2、檢查焦化發電機：機油平面，冷卻液平面。

2. Check the coking generator: oil level and coolant level.

3、日檢焦化發電機有無損壞、摻漏，皮帶是否松弛或磨損。

3. Daily check whether the coking generator is damaged or leaked, and whether the belt is loose or worn.

（2）每周保養：

(2) Weekly maintenance:

1、重復每日的A級焦化發電機檢查。

1. Repeat daily inspection of class a coking generator.

2、檢查空氣濾清器，清潔或更換空氣濾清器芯子。

2. Check the air filter, clean or replace the air filter core.

3、放出燃油箱及燃油濾清器中的水或沉積物。

3. Drain the water or sediment in the fuel tank and fuel filter.

移動焦化發電機電力：焦化發電機組的日常維護保養

Mobile coking generator power: daily maintenance of coking generator unit

4、檢查水過濾器。

4. Check the water filter.

5、檢查起動蓄電池。

5. Check the starting battery.

6、起動焦化發電機并檢查有無影響。

6. Start the coker generator and check for impact.

7、用清水冼冷卻器前后端的散熱片。

7. Clean the cooling fins at the front and rear ends of the cooler with clean water.

（3）有組織的維護

(3) Organized maintenance

有組織的維護使費用和工作量降到zui低水平，因為它是有組織的定期進行，而不是在機組處于緊急狀態時才要求進行的，定期維護的其它好處可能不會被明顯地看見，由于潛在故障可能在其發展之前發現，這節約了大修費用。同時，由于機組總是運行在良好狀態，將減少運行費用并增加機組壽命。

The organized maintenance reduces the cost and workload to the low level of Zui, because it is organized and carried out regularly, rather than required only when the unit is in an emergency state. Other benefits of regular maintenance may not be obvious. Since potential faults may be found before their development, this saves the overhaul cost. At the same time, since the unit always operates in good condition, the operation cost will be reduced and the service life of the unit will be increased.

所以說對于焦化發電機組，要勤觀察、勤檢查，發現故障，及時排除。這樣才能在安全順利的更為長久的使用起來，更多相關內容可以來我們網站http://www.hdlelisa.com咨詢！

Therefore, it is necessary to frequently observe and inspect the coking generator set, and timely eliminate the fault if found. Only in this way can it be used safely and smoothly for a longer time. More relevant content can be found on our website http://www.hdlelisa.com consulting service