1. Use: that is, use the diesel generator correctly. Before starting, shake the vehicle first to make the lubricating parts such as bearing shells get lubricating oil before starting. After start-up, it shall be put into operation when the water temperature reaches 40-50 ℃. Overload or low-speed operation for a long time is strictly prohibited. Before shutdown, unload the load and reduce the speed. After shutdown in winter, drain the cooling water when the water temperature drops to 40-50 ℃ (except for diesel generators filled with antifreeze). The diesel generator shall be maintained regularly on weekdays to keep the machine in good technical condition. Observe and check frequently, and eliminate faults in time.

2、磨：即磨合。這是延長柴油發電機使用壽命的基礎。無論是新的還是大修后的柴油發電機，都必須按規范進行磨合后，方能投入正常作業。

2. Grinding: namely running in. This is the basis for prolonging the service life of diesel generator. New or overhauled diesel generators must be run in according to the specifications before they can be put into normal operation.

3、檢：即經常檢查緊固部位。因康明斯柴油發電機組在使用過程中受震動沖擊和負荷不均等影響，螺栓、螺母容易松動。還有各部位的調整螺栓都要仔細檢查，以免造成因松動而損壞機件的事故。

3. Inspection: check the fastening parts frequently. Because Cummins diesel generator set is affected by vibration impact and uneven load during use, bolts and nuts are easy to loosen. In addition, the adjusting bolts of all parts should be carefully checked to avoid the accident of loosening and damaging the parts.

4、含有大量塵土，將會加速缸套、活塞和活塞環的磨損。若冷卻水不，會使冷卻系水垢增加，妨礙柴油發電機散熱，潤滑條件變差，機件磨損嚴重。若機體外表不凈，會使機體表面受到腐蝕，縮短使用壽命。

4. It contains a lot of dust, which will accelerate the wear of cylinder liner, piston and piston ring. If the cooling water is not, it will increase the scale of the cooling system, hinder the heat dissipation of the diesel generator, worsen the lubrication conditions and seriously wear the parts. If the body surface is not clean, the body surface will be corroded and the service life will be shortened.

5、足：即油足、水足、空氣足。若柴、柴油和空氣供應不及時或中斷，就會出現起動困難、400KW柴油發電機價格燃燒不良、柴油發電機功率功率下降、柴油發電機不能正常運轉等現象。若機油供不應求或中斷，會使柴油發電機潤滑不良、柴油發電機機件磨損嚴重甚至出現燒瓦現象。若冷卻水不足，會使機溫過高，功率下降，磨損加劇，降低使用壽命。

5. Sufficient: sufficient oil, water and air. If the supply of diesel, diesel and air is not timely or interrupted, there will be difficulties in starting, poor combustion of 400KW diesel generator price, reduction of diesel generator power, failure of diesel generator to operate normally, etc. If the oil supply is in short supply or interrupted, the diesel generator will have poor lubrication, serious wear of diesel generator parts, and even Bush burning. If the cooling water is insufficient, the machine temperature will be too high, the power will be reduced, the wear will be intensified, and the service life will be reduced.

7、調：即康明斯柴油發電機組的氣門間隙、配氣相位、供油提前角、噴油壓力以及點火正時等都應及時檢查并調整，以柴油發電機經常處于良好的技術狀態，方能節省燃油，延長使用壽命。

7. Adjustment: the valve clearance, valve timing, fuel supply advance angle, fuel injection pressure and ignition timing of Cummins diesel generator set shall be checked and adjusted in time, so that the diesel generator is often in good technical condition, so as to save fuel and prolong service life.

以上就是今天小編給大家提供的精彩內容，更多的精彩內容請點擊進入我們的官方網站：瓦斯發電機組http://www.hdlelisa.com

The above is the wonderful content provided by Xiaobian today. For more wonderful content, please click to enter our official website: gas generator set http://www.hdlelisa.com